Blodgett BC-20G Spécifications

BC-20E AND BC-20GCOMBINATION OVEN STEAMERINSTALLATION - OPERATION - MAINTENANCEBLODGETT OVEN COMPANYwww.blodgett.com44 Lakeside Avenue, Burlington, Ve

6InstallationPlumbing ConnectionsWATER CONNECTIONNOTE: Hot water maximizes steam production but is not required. Cold water may be supplied to both i

7InstallationElectrical ConnectionsBefore making any electrical connections to these units, check that the power supply is adequate for the voltage, a

8InstallationGas ConnectionGAS PIPINGA properly sized gas supply system is essential for maxi-mum oven performance. Piping should be sized to pro-vide

9InstallationGas ConnectionPRESSURE REGULATION AND TESTINGThe gas pressure to the appliance must be rated for each appliance while the burners are on

10InstallationFinal Check and AdjustmentsBEFORE SWITCHING THE APPLIANCE ONBefore applying power to the unit for the rst time, check for the following

11InstallationFinal Check Lists WARNING!!Final check list must be performed by a quali-ed installer only.ELECTRICAL CONTROL COMPARTMENT• Voltage to

12OperationSafety InformationThe information contained in this section is provided for the use of qualied operating personnel. Qualied operat-ing pe

13OperationManual Control1324568 7109111312151416Figure 5 CONTROLS IDENTIFICATION1. MODE SELECTOR SWITCH - turns power to the oven on or off. Allows

14OperationManual ControlTIMER COOKING1. Press the TIMER/PROBE KNOB (8) to select the timer mode. The TIMER LED lights.2. Turn the MODE SELECTOR Swi

15OperationMenuSelect™ Control56873124119101312141516171918202122Figure 6 CONTROL DESCRIPTION1. START/STOP KEY - press to start, cancel or pause the

Your Service Agency’s Address:ModelSerial numberOven installed byInstallation checked by

16OperationMenuSelect™ ControlOVEN STARTUP1. Be sure the gas shutoff switch or circuit breaker switch below the control panel are in the on position.

17OperationMenuSelect™ Control6. Connect the core probe to the PROBE CONNEC-TION (21) at the bottom of the control.NOTE: Do not connect the prob

18OperationMenuSelect™ ControlPRODUCT PROGRAMMINGEntering the Program Mode1. Press the PROGRAM KEY (15). If the control is pass-word protected, the d

19OperationMenuSelect™ ControlMANAGER PROGRAMMINGEntering the Manager Program Mode1. Press the MAINTENANCE KEY (17). If the control is password prote

20MaintenanceSpray Bottle Operating ProcedureNOTE: Only use a commercial oven cleaner/degreaser with the spray bottle. DO NOT use chemicals that are n

21MaintenanceCleaning and Preventive MaintenanceDAILY CLEANINGCleaning the InteriorDaily cleaning of the oven is essential for sanitation, and to en

22MaintenanceFlushing the BoilerSTANDARD CONTROLA ush of the boiler is required every 24 hours and hap-pens either automatically or can be initiated

23MaintenanceDelimingDeliming of the steam generator is the single most im-portant preventative maintenance task. Lime will build up inside the steam

24MaintenanceDeliming4. When the delime lamp goes out, the oven can be used normally.To Cancel the Deliming Process1. To cancel the deliming process

25Maintenance4. Turn the dial to highlight “START DELIME”. Press the center of the dial to select.1. START DELIME2. DELIME INT 2 DY3. NEXT DELIME4. D

TABLE OF CONTENTSINSTALLATIONThe Blodgett Combi-Oven/Steamer ... 4Description of the Combi-Oven/Steamer ...

26MaintenanceDelimingDELIMING INTERVAL SETTINGRefer to gure to determine the correct deliming inter-val for your appliance. Find your locati

4InstallationThe Blodgett Combi-Oven/SteamerThe Blodgett Combi-Oven/Steamer offers a completely new method of cooking. With the Oven/Steamer you have

5InstallationDescription of the Combi-Oven/SteamerABOUT THE OVEN/STEAMERBlodgett Combi-Oven/Steamers are quality produced us-ing high-grade stainles

2InstallationOwner’s ResponsibilitiesPLUMBING SPECIFICATIONS - BC-20E & BC-20GWATERWater pressure 40 PSI min/116 PSI maxWater connection 3/4” Hose

3InstallationOwner’s ResponsibilitiesELECTRICAL RATINGS - BC-20GVOLTAGE PHASE AMPS RECEPTACLE115 1 20 Nema 5-20R dedicated receptacleBlodgett recommen

4InstallationLocation and VentilationLOCATIONThe well planned and proper placement of your appliance will result in long term operator convenience and

5InstallationUtility Connections - Standards and CodesTHE INSTALLATION INSTRUCTIONS CONTAINED HEREIN ARE FOR THE USE OF QUALIFIED INSTAL-LATION AND SE